Openable Chamber KVH800 Small Waste Oil Heater Easy to Clean Ash

Product DescriptionModelKVH800Heat Supply Areabelow 200sq.m (below 2000sq.ft)Size(LxWxH)80x50x50cmN.W100kgHeat Exchangeropenable stainless steel combustion chamberDraught Fan Systemtwo 322mm(dia) YWFOil Consumption2-3L/HOutput Power14-55KWMax.Output Heat30,000Kcal/H(120,000Btu/H)Air Output1330m3/HFan Motor2x100WChimney Diameter90mmPower Supply220V 50HZ or 110V 60HZWorking Pressure0.5bar(7PSI)
Must work with external air compressor,smallest capacity is 0.3-0.5cbm/minFuelall kinds of waste oil,waste mixed oil,diesel oilApplicationgarage,workshop,chicken house etc
(release warm wind,competely safe to use)✔available fuel listused engine/motor oilused crankcase oilused transmission oilused hydraulic oilused synthetic oilwaste machine shop cutting oilused grades #1,#3,#4 heating oilsused tyre/rubber pyrolysis oilused diesel oilused cooking oil/used vegetable oilsoybean oil/animal fat oilused mixed oilwaste car/truck oilwaste plastic oilsewage/sump oilcorrupt/dirty oilbitumen/asphalt oilliquid residual oildiesel oil/clean oil/refined oil.........✘gasoline,heavy oil,water



★removable window shade


★spray treatment in the casing surface





★ openable chamber,easy to clean ash



★100%sealed




★two fans


★chimney connector on the top,no smoke
★easy operation panel



★full-automatic


★5 minutes to release warm air



★external 54L oil tank,whole oil pump&filter system etc are included







★high sensitive temperature sensor included
Test&Manual Video:
https://youtu.be/G-Wkp6D-NHsSafety Precautionselectro-magnetic induction oil floats

Stop the burner when oil level is not between the two oil floatPhoto cell
Stop the burner when there is no lightoil pump
Stop the burner when oil pumps more than 2 minsBuyer Feedback
Pictures from USA CustomerFAQ
1.misfunction and solution: ●mal button lights,quick flicker turns to slowly flicker. Press reset button to see if burner is back to work.If not,take off the photo cell and wipe.●Mal button is alway light,reset button can't press. In this case,power off and connect the power again. It is a normal misfunction,because new burner,there is no oil in oil pump and filter.Pump can't supply oil within 2 mins,oil float gives message to print board,to shut down the burner for protection. ●Heat button is lighting,then light the mal button. There is too much water in the oil. use the valve in the bottom of the small tank to leak water. Stilling oil for a night,let me water and oil seperate. ●Ignition rod is striking fire,but no fire. Use the tool to remove the nozzle,check if it has been blocked,change the rubber pad too. The tool and rubber pads are also with the burner,we send you for this situation. If you meet other problem,contact us first .
2.Have you improved and innovated your product? As a factory,we improve and innovate all the time,we take customers requirment seriously.For example: We change the print board's programme to reach 30s purge.some countries have demand for that. We change the manual air flap to automatic system.To low down the noise. We use one air compressor for two or three air solenoid system,to reduce the cost for customer. If you have any requirement for burner,please let me know.
3.Customers have their own oil system,no need of oil pump system.Is that ok? Yes,it's ok.Please let me know first.To see if we have to change the print board accordingly.
4.Do customers need to prepare the pre-filer? No.We have it with the burner.If you have your own ideas,then it's ok.
5.Comparing waste oil burner within air pump,some diesel modified burner and other waste oil
burnerbrand,what's the difference?
We are true waste oil system,differ from waste oil burner within compressor,diesel modifed burner or other brand.
For example,we design the photo cells specifically for waste oil burner,more sensitive and precision than photodiodes.
6.Is necessary the burner working with 1 unit outside compressor?
Yes.It is.Because the simple principle is high pressure atomizing. 7.what's the air compressor would match your burner&heater? KV-03,KV-05,KV-10,KV-20,KV-30 matches around 0.3-0.5cbm/min(5-9L/s) ac KVH-1000,KVH-2000,KVH-5000 and KVH-6000 matches around 0.3-0.5cbm/min(5-9L/s) ac Unit conversion:1cmb/min=16.7L/s8.I am not so familiar about waste oil burner,which type should I choose?
It's ok.Contact us,we will guide you the best burner.
9.Can I pay by credit card instead of going to bank? Yes,it's ok.Just let us know.One Package ServiceMachine Tool WorkshopFoundry Workshop
Assembled by handwork
Fire test,debug,record before
leaving factory
package according to different
situation
Transport
●By express,such as dhl
●By air
●By sea
●By landAfter-sale service

●check carefully when you receive

the parcel,accessories are somewhere within the parcel.
●check the manual and video

carefully before operation.Manual is not within the parcel,your sales will send to your email.
●If there is any trouble when using

the machine,please take a video for

us.We will tell you how to manage.
Refund Guarantee

●We do all the business by alibaba trade assurance order.In this case,if we fail to product quality and delivery time,alibaba will pay your loss.
●You can put an trade assurance order directly or ask your sales to draft it for you.
Contact&Social Page
Contact name: Helen Jiang
ID:cn1513245264
Phone/whatsapp/wechat: 86-130 1251 3355
Fax: 0532-68876247
Skype: live:15110a39c97c5b18

email:helenjiang_sales1@ kingweienergy.com(no blank after @)
linkedin: https://cn.linkedin.com/in/waste-oil-burner-supplier-bb4770ba
facebook: https://www.facebook.com/wasteoilburnersupplier
youtube: https://www.youtube.com/channel/UCrIv63Y1ri9tFY_g8DzKO4Q
https://www.youtube.com/channel/UCd2DtCB7ma4BzUwCRPVs4ow
shop on alibaba:Http://jinweijieneng.en.alibaba.com/
Office&factory address:No997 Wangsha Road Chengyang District Qingdao Shandong ChinaModel Comparison Kingwei Waste Oil Heater ComparisonModelOil Consumption(liter per hour)output power(kw)max.output heat(btu/h)heat supply area(sq.m)FeatureKVH800
2-314-5512,000below 200▪Small light economic
▪Hanging,save space
▪External 54L oil tank included▪openable chamber,asbestos free
KVH10003-530-6020,000200-600▪Hanging type
▪External 100L oil tank included▪warm air outlet:window-shades
KVH20006-880-12040,000600-800▪Portable type▪popular in garage
▪Inside 100L oil tank
▪warm air outlet:window-shadesKVH50006-880-12040,000800-1000▪warm air outlet:two independent duct▪special for chicken house
▪Portable type
▪Inside 100L oil tankKVH600013-15150-20080,0001000-1200▪big power▪warm air outlet:four independent duct
▪portable▪inside 100L oil tank
▪apply for both indoor and outdoor

Unit conversion:
1 liter≈0.24gal(American&UK)
1 Kcal/h=4Btu/h
1 square meter≈0.1 square foot
*heat supply area also depends on space height