Product DescriptionModelKVH2000Heat Supply Area600-800sq.m(6000-8000 sq.ft)Size(LxWxH)95x56x174cmHeat Exchangerstainless steel combustion chamberDraught Fan Systemfour 350mm(dia) YWFOil Consumption6-8l/hOutput Power80-120kwMax.Output Heat100,000Kcal/H(400,000Btu/H)Air Output12000m3/HFan Motor0.6kwChimney Diameter140mmPower Supply220V 50HZ Or 110V 60HZWorking Pressure8bar(0.8mpa 116PSI)Must work with one unit external air compressorrecommended parameter is 0.3-0.5cbm/minFuelall kinds of waste oil,waste diesel oil,diesel oilApplicationindoor:garage,workshop,factory etc
outside:playground,construction site,tunnel(output only hot wind,competely safe to use)✔ available fuel listused engine/motor oilused crankcase oilused transmission oilused hydraulic oilused synthetic oilwaste machine shop cutting oilused grades #1,#3,#4 heating oilsused tyre/rubber pyrolysis oilused diesel oilused cooking oil/used vegetable oilsoybean oil/animal fat oilused mixed oilwaste car/truck oilwaste plastic oilsewage/sump oilcorrupt/dirty oilcontaminated/polluted oilliquid residual oildiesel oil/clean oil/refined oil...........✘ gasoline,heavy oil,water
waste oil burner
Oil pump&filter system
setthe demand temperature,machine will work automatically until reach it.Stop automatically then,restart by itself(There is a iron rod to detect ambient temperature)
Video:
https://youtu.be/jNQxHc1ptSY (waste oil heater manual video)
https://www.youtube.com/channel/UCd2DtCB7ma4BzUwCRPVs4ow (our youtube channel)
Safety Precautionsmicro switch
Stop the burner when oil level is not between the two oil floatPhoto cell
Stop the burner when there is no lightoil pump
Stop the burner when oil pumps more than 2 minsBuyer FeedbackFAQ
1.misfunction and solution: ●mal button lights,quick flicker turns to slowly flicker. Press reset button to see if burner is back to work.If not,take off the photo cell and wipe.●Mal button is alway light,reset button can't press. In this case,power off and connect the power again. It is a normal misfunction,because new burner,there is no oil in oil pump and filter.Pump can't supply oil within 2 mins,oil float gives message to print board,to shut down the burner for protection. ●Heat button is lighting,then light the mal button. There is too much water in the oil. use the valve in the bottom of the small tank to leak water. Stilling oil for a night,let me water and oil seperate. ●Ignition rod is striking fire,but no fire. Use the tool to remove the nozzle,check if it has been blocked,change the rubber pad too. The tool and rubber pads are also with the burner,we send you for this situation. If you meet other problem,contact us first .
2.Have you improved and innovated your product? As a factory,we improve and innovate all the time,we take customers requirment seriously.For example: We insulate copper in demand of NZ customer need. We change the print board's programme to reach 30s purge.some countries have demand for that. We change the manual air flap to automatic system.To low down the noise. We use one air compressor for two or three air solenoid system,to reduce the cost for customer. If you have any requirement for burner,please let me know.
3.Customers have their own oil system,no need of oil pump system.Is that ok? Yes,it's ok.Please let me know first.To see if we have to change the print board accordingly.
4.Do customers need to prepare the pre-filer? No.We have it with the burner.If you have your own ideas,then it's ok.
5.Comparing waste oil burner within air pump,some diesel modified burner and other waste oil
burnerbrand,what's the difference?
We are true waste oil system,differ from waste oil burner within compressor,diesel modifed burner or other brand.
For example,we design the photo cells specifically for waste oil burner,more sensitive and precision than photodiodes.
6.Is necessary the burner working with 1 unit outside compressor?
Yes.It is.Because the simple principle is high pressure atomizing. 7.what's the air compressor would match your burner&heater? KV-03,KV-05,KV-10,KV-20,KV-30 matches around 0.3-0.5cbm/min(5-9L/s) ac KV-50,KV-60 matches around 0.7-1cbm/min(11-17L/s) ac KV-90,KV-120 matches around 1.2-1.5cbm/min(20-25L/s) ac KVH-1000,KVH-2000,KVH-5000 and KVH-6000 matches around 0.3-0.5cbm/min(5-9L/s) ac Unit conversion:1cmb/min=16.7L/s8.I am not so familiar about waste oil burner,which type should I choose?
It's ok.Contact us,we will guide you the best burner.
9.Can I pay by credit card instead of going to bank? Yes,it's ok.Just let us know.One Package ServiceMachine Tool WorkshopFoundry Workshop
Assembled by handwork
Fire test,debug,record before
leaving factory
package according to different
situation
Transport
●By express,such as dhl
●By air
●By sea
●By landAfter-sale service
●check carefully when you receive
the parcel,accessories are somewhere within the parcel.
●check the manual and video
carefully before operation.Manual is not within the parcel,your sales will send to your email.
●If there is any trouble when using
the machine,please take a video for
us.We will tell you how to manage.
Refund Guarantee
●We do all the business by alibaba trade assurance order.In this case,if we fail to product quality and delivery time,alibaba will pay your loss.
●You can put an trade assurance order directly or ask your sales to draft it for you.
Contact&Social Page
Contact name: Helen Jiang
ID:cn1513245264
Tel/whatsapp: 86-130 1251 3355
Fax: 0532-68876247
Skype: dayaguixiu
email:helenjiang_sales1@ kingweienergy.com(no blank after @)
linkedin: https://cn.linkedin.com/in/waste-oil-burner-supplier-bb4770ba
facebook: https://www.facebook.com/wasteoilburnersupplier
pinsterest: https://www.pinterest.com/kingwei_sales1/
vk:http://vk.com/id315837235
youtube: https://www.youtube.com/channel/UCrIv63Y1ri9tFY_g8DzKO4Q
https://www.youtube.com/channel/UCd2DtCB7ma4BzUwCRPVs4ow
shop on alibaba:Http://jinweijieneng.en.alibaba.com/
address:Vanke Golden Square No 216 Chongqing South Road Qingdao ChinaRelated ProductsKVH-1000
Hanging type
30-60kw
read moreKVH-5000
Portable type
80-120kw
read moreKVH-6000
Portable type
150-200kw
read more